IICT6防爆照明配电箱，铸铝BXM53防爆照明配电箱生产厂家

IICT6防爆照明配电箱，铸铝BXM53防爆照明配电箱生产厂家-乐清威创防爆科技有限公司专业生产：防爆照明箱，防爆配电箱厂家，挂墙式防爆配电箱，立地式防爆配电箱，内装正泰元件防爆配电箱，内装施耐德防爆配电箱...
BXM53 explosion-proof lighting distribution box （IIC）
1. 适用范围和用途
1 scope of application and use
BXM53防爆照明配电箱是根据国家标准GB3836.1～2－83设计和制造的,适用于1区或2区中含有爆炸性混合物Ⅱ类B级T6组及以下的危险场所，作为交流50Hz，额定电压至380V，分支回路额定电压380V，且具有过载、失压、短路保护。
BXM53 explosion-proof lighting distribution box is based on the national standard GB3836.1 - 2 - 83 design and manufacturing, can be used in zone 1 or 2 zones containing explosive mixtures of class II B T6 group and dangerous places below, as the exchange of 50Hz, rated voltage up to 380V, the branch circuit of rated voltage 380V, and has the overload, loss pressure, short circuit protection.
2 产品型号及含义
2 product models and implications
Ｂ ＸM 53 Ｐ － K
B XM 53 P K
控制配电
Control of distribution
M：照明 D：动力
M: D: dynamic lighting
箱类
Box
防爆照明配电箱
Explosion-proof lighting distribution box
2．2 配电箱的防标志为dⅡBT6；
Mark 2.2 distribution box for D Ⅱ BT6;
2．3 配电箱进线配用电缆zui大外15mm；
The 2.3 lines into the cable distribution box with maximum 15mm;

IICT6防爆照明配电箱，铸铝BXM53防爆照明配电箱在下列情况下能够可靠工作
3 BXM53 explosion-proof lighting distribution box can work reliably in any of the following circumstances
3．1 周围空气温度上限值不超过+40℃，下限值不低于-20℃，且24小时内的平均值不超过+35℃；
3.1 the temperature of the air around the upper limit of not more than +40 ℃, lower value not lower than -20 ℃, and within 24 hours of the average value of not more than +35 DEG c;
3．2 安装地点的海拔不超过2000m；
3.2 installation site elevation not exceeding 2000m;
3．3 安装地点zui湿月平均zui大相对湿度不超过95%，同时该月的月平均温度不低于+25℃；
3.3 installation location the wettest month average maximum relative humidity of not more than 95%, while the average monthly temperature of the month is not lower than +25 ℃;
3．4 在无剧烈振动、摇动及冲击的地方；
3.4 in no violent vibration, swing and impact;
3．5 安装类别为Ⅱ、Ⅲ；
3.5 installation of class II, iii;
3．6 防护等级：IP54。
3.6 protection grade: IP54.
BXM53-6 防爆照明配电箱 6
BXM53-6 explosion-proof lighting distribution box 6
BXM53-8 防爆照明配电箱 8
BXM53-8 explosion-proof lighting distribution box 8
BXM53-10 防爆照明配电箱 10
BXM53-10 explosion-proof lighting distribution box 10
BXM53-12 防爆照明配电箱 12
BXM53-12 explosion-proof lighting distribution box 12
BXM53-4K 防爆照明配电箱 1 4
BXM53-4K explosion-proof lighting distribution box 14
BXM53-6K 防爆照明配电箱 6
BXM53-6K explosion-proof lighting distribution box 6
BXM53-8K 防爆照明配电箱 8
BXM53-8K explosion-proof lighting distribution box 8
BXM53-10K 防爆照明配电箱 10
BXM53-10K explosion-proof lighting distribution box 10
BXM53-12K 防爆照明配电箱 12
BXM53-12K explosion-proof lighting distribution box 12
IICT6防爆照明配电箱，铸铝BXM53防爆照明配电箱主要结构
The main structure of the 4 BXM53 explosion-proof lighting distribution box
4．1 主要结构
The 4.1 main structure
配电箱外壳系采用ＺＬ102铸造铝合金制成隔爆型外壳，主腔内装有电流表、按钮、指示灯、*转换开关等元件，并设有独立的接线箱，使进出线更加安全、方便、连接可靠，采用钢管或电缆布线方式。
Distribution box shell is made by ZL102 flameproof enclosure aluminium alloy casting, the main cavity is provided with a current meter, button, indicator light, universal switch element, and a junction box, independent, which import more secure line, convenient, reliable connection, with steel pipe or cable wiring mode.
IICT6防爆照明配电箱，铸铝BXM53防爆照明配电箱安装、调整使用与维护
The use and maintenance of 5 installation, adjustment
5．1 用户在安装之前应检查配电箱铭牌上所列数据与说明书中基本参数是否相符，并应详细检查配电箱内部是否正常，元件是否损坏，导线是否松动、脱落，螺钉是否松动、缺少；
5.1 users should check the distribution box nameplate on the column data and instructions in the basic parameters are consistent with prior to installation, and should be internal to examine in detail the distribution box is normal, components are damaged, wire is loose, fall off, screw is loose, the lack of;
5．2 安装时应注意电缆由出线套、金属垫圈、橡胶密封圈依次放入引入装置内，待接好线以后，将出线套旋紧，使之严格密封，再将压线板安装好，防止电缆拔脱；
5.2 installation should note the cables from the outlet sleeve, metal gasket, rubber sealing ring turn into into the device, after the connect the wire outlet sleeve, screw, make strict sealing, the pressing plate is installed, prevent the cable pulling;
5．3 经检查无误以后，接好进出线和内外接地线，即可通电使用；
5.3 through the check and correct after all, connect line and ground wire, electricity can be used;
5．4 检查与维修必须在断开前级电源后方可进行，并严格禁止在大盖打开状态下进行通电试车（在安全的情况下除外），检修完毕后应关好大盖，并把螺栓紧固好才能通电使用；
5.4 inspection and repair must be disconnected before the power before, and strictly prohibit the cover open state under the power-on test （except in the case of absolute security）, after maintenance should close the cover, and the bolts to the use of electricity;
5．5 检查与维修过程中，不得损坏隔爆面，并应保持清洁，合上大盖前应涂204－1置换型防锈油。
5.5 inspection and repair process, shall not damage the flameproof surface, and should be kept clean, close the cover should be coated with 204 - 1 replacement of anti-rust oil.
IICT6防爆照明配电箱，铸铝BXM53防爆照明配电箱保管及运输
6 storage and transportation
6．1 配电箱应放置在不能受支阳光直接照射和雨雪淋湿的仓库中保管，不得倾斜、倒立放置；
6.1 distribution box should be placed under a direct sunlight and rain drenched the warehouse in not in custody, not tilt, placed upside down;
6．2 配电箱在运输过程中应防止剧烈巅簸、振动和受到外力撞击、磕碰的现象，并按照工作状态进行放置。
6.2 distribution box should avoid strenuous summit toss, vibration and by external impact, collision phenomenon in the process of transportation, and in accordance with the state of work place.
BXM53防爆照明动力配电箱电气原理图-无总开关
BXM53 explosion-proof lighting power distribution box electrical diagram - no switch
BXD53防爆动力配电箱电气原理图-无总开关
BXD53 explosion-proof power distribution box electrical diagram - no switch
BXM53防爆照明配电箱电气原理图-带总开关
BXM53 explosion-proof lighting distribution box and electrical schematic diagram, with master switch
BXD53防爆照明动配电箱电气原理图-带总开关
BXD53 explosion-proof lighting dynamic electrical power distribution box diagram - with master switch
BXM53（BXD53）防爆照明（动力）配电箱电气原理图-不带总开关
BXM53 （BXD53） explosion-proof lighting （dynamic） electrical power distribution box diagram - without master switch
BXM53（BXD53）防爆照明（动力）配电箱电气原理图-带总开防爆照明（动力）配电箱BXM53（BXD53）-防爆照明（动力）配电箱BXM53（BXD53）-4K
BXM53 （BXD53） explosion-proof lighting distribution box （dynamic） electrical schematic diagram with the total open explosion-proof lighting distribution box （power） of BXM53 （BXD53） - explosion-proof lighting distribution box （power） of BXM53 （BXD53） -4K
防爆照明（动力）配电箱BXM53（BXD53）-6
Explosion-proof lighting distribution box （power） of BXM53 （BXD53） -6
防爆照明（动力）配电箱BXM53（BXD53）-6K
Explosion-proof lighting distribution box （power） of BXM53 （BXD53） -6K
防爆照明（动力）配电箱BXM53（BXD53）-8
Explosion-proof lighting distribution box （power） of BXM53 （BXD53） -8
防爆照明（动力）配电箱BXM53（BXD53）-8K
Explosion-proof lighting distribution box （power） of BXM53 （BXD53） -8K
防爆照明（动力）配电箱BXM53（BXD53）-10
Explosion-proof lighting distribution box （power） of BXM53 （BXD53） -10
防爆照明（动力）配电箱BXM53（BXD53）-10K
Explosion-proof lighting distribution box （power） of BXM53 （BXD53） -10K
防爆照明（动力）配电箱BXM53（BXD53）-12
Explosion-proof lighting distribution box （power） of BXM53 （BXD53） -12
防爆照明（动力）配电箱BXM53（BXD53）-12K
Explosion-proof lighting distribution box （power） of BXM53 （BXD53） -12K